Problems drying out chili sauce and in to a powder
I make a chili sauce that I want to turn in to a seasoning.
I’ve made a few batches by spreading the sauce out on silicon sheets in a thin layer and baking it at a low temperature until it dries. Then I peel the dried sauce and blend/crush it until it reaches a powder like consistency.
This works well for small batches (though still not ideal), but it doesn’t scale well. If I’m trying to make a big batch, is there a way that would allow me to make more than 2 sheets at a time? Perhaps a technique where the layer of sauce doesn’t have to be so thin? I’m open to ideas and experiments.
I tried using a Nesco dehydrator - the top layers would dry, but be very difficult/impossible to peel off. The lower levels in the dehydrator don’t get hot enough to fully dry the sauce out.
Thanks in advance!
Best Answer
Ask around for someone who has an Excalibur or similar style tray dehydrator. One of these coupled with a silicone (or siliconized) sheet on each tray should get you where you want to be. You might want to add a thickening agent of some sort if your recipe does not have one already.
Why this style? The fan is across the back of the machine and blows evenly across all of the trays instead of the fan on top down through the middle type like the Nesco.
Good luck.
Pictures about "Problems drying out chili sauce and in to a powder"
Can you turn sauce into powder?
Spread sauce on the dehydrator trays, covered with non-stick sheets or parchment paper. Dry at 125F/52C for 8-10 hours until brittle. Brake down tomato sauce bark into small chunks; then grind them in a coffee grinder or food processor into a powder.How do you dry pulp from hot sauce?
Spread the pulp out over dehydrator sheets to a maximum of \xbc inch thickness. Use extra trays if needed. Dehydrate the pulp at 125 degrees F. for 8-10 hours, or until the pulp is completely dried through.Should you strain hot sauce?
Strain the Hot SauceThe finished sauce should be strained through a fine mesh sieve to remove any small pieces of seed or pulp that may remain. Be sure to press down on the pepper pur\xe9e as you strain it to extract all of its juices.How to Make Hot Sauce with Dried Peppers - Chili Pepper Madness
Sources: Stack Exchange - This article follows the attribution requirements of Stack Exchange and is licensed under CC BY-SA 3.0.
Images: Mareefe, Karolina Grabowska, Karolina Grabowska, Mareefe